Winter Ventilation: 8 Reminders to Keep Your Pigs Healthy

(Provided by Pipestone)

By Dr. Cameron Schmitt, DVM, Pipestone Veterinary Services 

With winter upon us, there are many things to keep in mind when it comes to ventilation in the barn. Here are eight things to remember as you brave the cold this season. 

1. Set Points
Set points are what you tell the barn to maintain temperature at. Typically, barns will be 1 to 2 degrees cooler most of the time during winter months. If you want the actual temperature to be 70 degrees for example, you may need to run your set point at 71 degrees to average 70 degrees. Every barn is slightly different.

2. Soffets
Soffets are important to get air into your attic and then into the room. Soffets commonly get plugged with dust or dirt from harvest and can be further blocked with frost or snow. Take a long-handled broom periodically on a barn walk around to clean soffets off to allow maximum air flow into your attic. Snow doors should be closed on north- or west-facing outer walls to prevent snow drifting in your attic.  

3. Heater Off-sets
Heater off-sets – most commonly, you will want your heater to come on at 1.5 to 2 degrees below your set point. The offset is important to check to make sure you are not warming up your barn over the set point. If you are, your fans begin to ramp up to cool the barn down again and you have wasted that heat. It’s simple to check. Watch your controller’s temperature reading when the heater is on. When the heater shuts off, the room will continue to warm. Watch to find the temperature at which it peaks at and then begins to fall. Ideally, the room warms up to just the desired set point and then begins to cool again. Then, no wasted heat is blown out by ramping up fans. If the temperature overruns your set point and fans begin to ramp up, you need to widen your off-set.

4. Back-up Heaters and Alarms
Check your back-up thermostats and alarms to come on at 55 degrees to 60 degrees. To make them work, turn them up and see your heater kick on.

5. Air Speed from Inlets 
When you are in minimum ventilation, you still want good air speed for mixing of air from the inlets. Purchase an anemometer for around $50 to give you your exact speed of air from the inlets. Target to get 400 feet per minute. A good rule of thumb if you don’t have an anemometer is to stand 10-12 feet away from the inlet – you should feel air on your forehead if it is working around 400 feet per minute.

6. Humidity
Rheostats are notoriously bad in pig barns as they only typically work for about six months. Most farms have a great permanent rheostat – the water lines. Ground water should be around 57 degrees Fahrenheit year-round. If your water lines are dripping in the middle of the room, you are running too high humidity and likely need to increase air exchange (increase minimum ventilation percentage).

7. Pig Comfort
Pigs have three “rooms” in their house: a kitchen, a bedroom and a bathroom. After pigs have established their house, you should only find around 25% of their space serving as the bathroom. If the dunging pattern is greater than this, you may need to adjust your ventilation.

8. Temp Probes
Check each individual temperature probe reading at the controller. They should only vary by one degree. If you find a variance greater than that, you likely need to change one of the probes out.  

More from Farm Journal's PORK:

The COVID-19 Wild Card: Uncertainty Dominates Global Pork Outlook

 

SHIC-Funded Study on Feed Goes Beyond Mathematical Half-life Calculations

5 Pork Industry Opportunities: Keep Swine Disease Out

Why Collaboration Made All the Difference: SHIC Unveils 2021 Progress Report

 

Latest News

Hogs and Pigs Report: How Will Increase in Pigs Saved Per Litter Impact the Pork Outlook?
Hogs and Pigs Report: How Will Increase in Pigs Saved Per Litter Impact the Pork Outlook?

Of all the numbers in the latest USDA Hogs and Pigs Report, the number that caught economists’ eye was pigs saved per litter. Here's why Steve Meyer, Ever. Ag senior economists, says this is a number to watch.

Why You Need to Understand How USDA Purchase Programs Work
Why You Need to Understand How USDA Purchase Programs Work

With pork producers facing prolonged economic headwinds, recent USDA commodity purchases of pork offer relief at pivotal times. It’s important to understand how these programs work, says NPPC president Lori Stevermer.

Get the Facts Straight on Highly Pathogenic Avian Influenza
Get the Facts Straight on Highly Pathogenic Avian Influenza

Now that the mystery illness impacting some dairy herds has been revealed as the same strain of Highly Pathogenic Avian Influenza that has been impacting the U.S. poultry flock, pork producers are asking questions.

Merck Introduces Sequivity with Microsol Diluvac Forte Adjuvant Prescription Vaccine
Merck Introduces Sequivity with Microsol Diluvac Forte Adjuvant Prescription Vaccine

Merck Animal Health announced it has received license approval from the USDA for Sequivity with Microsol Diluvac Forte adjuvant prescription vaccine for use in gilts and sows. 

What Does the Next Generation of the Pork Industry Want?
What Does the Next Generation of the Pork Industry Want?

It’s easy to make assumptions about what others think, but recent research funded by the Indiana Pork Producers Association and the Indiana Soybean Alliance proves it’s always better to go to the source itself.

Skills Survey Reveals U.S. Agriculture & Food Industry Workforce Needs and Gaps
Skills Survey Reveals U.S. Agriculture & Food Industry Workforce Needs and Gaps

U.S. employers report challenges in finding suitable job candidates with work-ready skills to fill open roles in ag. The AgCareers.com U.S. Skills Survey offers insights, data and trends to address skill development.